Steel beam replacement & repair · Dungannon
Steel beam replacement & repair in Dungannon
Steelwork, approvals and making good for steel beam replacement & repair in Dungannon and nearby.
- Survey, design and installation in one
- Covering BT71
- Inspected before it is covered
- Free survey visit
- Engineer's calculations arranged
- Building control handled
- Fixed written price once scope is agreed
- England, Wales, mainland Scotland & NI
About our steel beam replacement & repair service in Dungannon
Our steel beam replacement & repair service in Dungannon covers everything from the first visit to the completion paperwork. Our coverage runs across Mid Ulster, so nearby villages are included too. Postcode districts we cover here include BT71.
We start with a survey visit, arrange an engineer's inspection, then carry out whatever repair the engineer specifies, from new bearings to strengthening or full replacement. We handle building control and the temporary propping, and you get an itemised written quote before anything starts.
Key points for your project
- Replacing a beam that is already carrying load is more delicate than fitting a new one. Props go in on both sides before anything is cut, with spreaders above and below, and the old steel is often cut into sections to lift it out safely.
- Repairs are usually more contained than a new opening because the room layout stays the same. The main disruption is stripping the boxing, propping the floor above and the dust from cutting steel, with the ceiling and walls around the beam replastered afterwards.
- A repair only lasts if the cause is dealt with too. A leaking roof, blocked gutter or bridged damp-proof course that rusted the beam needs fixing first, otherwise new protective coatings will break down in the same way.
- Beams fitted without calculations, whether decades ago or more recently without approval, may be smaller than the loads require, particularly in shop conversions and older knock-throughs. An engineer can check the existing section against the actual loads and say whether it is adequate.
- Shop beams over old shopfronts are a common repair job. They often carry the whole front wall of the upper floors, sit behind fascias where rain gets in, and may have been cut or altered when shopfronts were replaced in the past.
Four stages, one team
Survey in Dungannon
We visit, look at the wall and what sits above it, measure the opening and note services, access and how the steel can be brought in.
Engineer's design
A structural engineer sizes the beam, padstones and any posts, and sets out the temporary support needed while the wall is out.
Building control
A full plans application or building notice goes to Mid Ulster District Council under the Building Regulations (Northern Ireland) 2012 before work begins.
Install and sign-off
Props go in, the opening is formed, the steel is set and packed, building control inspects it, and we make good.
What does steel beam replacement & repair cost in Dungannon?
As a guide, budget £1,700–£4,750 including VAT for steel beam replacement in Dungannon, based on published UK cost guides adjusted for prices in Northern Ireland (-14%).
| Job | Typical guide range | What it usually covers |
|---|---|---|
| Steel beam replacement | £1,700–£4,750 | Propping, removing the failed beam, new steel on proper bearings, approval and making good |
| Fire protection to a steel beam | £130–£520 per beam | Fire-rated board boxing or an intumescent coating system as specified |
| Building control fees | £220–£560 | Building notice or full plans fee and inspections; varies by council or approver |
| Shop or commercial structural opening | £4,300–£12,900 | Transfer beam and columns for opening units together or forming a shopfront opening |
Figures include our approximate regional adjustment for prices in Northern Ireland (-14%) and are rounded. How these figures are worked out.
Building control and neighbours in Dungannon
Removing a load-bearing wall in Northern Ireland needs building control approval from the council. Mid Ulster District Council covers Dungannon. The engineer's calculations support the application, and a completion certificate is issued after the final inspection.
Northern Ireland has no Party Wall Act, so there is no statutory notice to serve. Where the steel bears into a shared wall, the title deeds and the general law apply, and agreeing the work with your neighbour in writing first is good practice.
Steel beam replacement & repair in Dungannon: your questions
Do I need a party wall agreement for steel beam replacement & repair in Dungannon?
There is no Party Wall Act in Northern Ireland. Your title deeds and the general law apply instead, so agree the work with your neighbour in writing before it starts.
Can you work on older or listed homes in Dungannon?
Yes. Older homes often have lime mortar, timber lintels or shallow footings, which the engineer allows for. Listed buildings need listed building consent for internal structural changes as well as building regulations approval, and that must be in place first.
Can a rusty steel beam be repaired?
Often, yes. Surface rust can usually be cleaned back to sound steel and treated with a protective coating. Where corrosion has eaten into the flanges or web, the engineer works out the remaining strength and decides whether plating will restore it or the beam needs replacing. The source of the moisture must be fixed as well.
Can an old shop beam be replaced while the flat above is occupied?
Often, yes, with careful planning. The front wall and floors above are propped from inside the shop, and sometimes from outside, before the old beam is cut out. Occupants can often stay in if the engineer is satisfied with the propping, though there will be noise for a few days. Where the flat is separately owned, access and consents need agreeing in advance.
Why has my steel beam sagged?
A beam usually sags because it is too small for the load, the load has increased since it was fitted, or its bearings have crushed or moved. Every beam bends slightly within design limits, but a visible dip or new cracking suggests something has changed. An engineer can measure it and identify the cause.
Do you also work near Dungannon?
Yes. We also cover nearby towns including Cookstown, Portadown, Craigavon and Magherafelt.